| 1. |
- Forghani Targhi, Bita, 1973, et al.
(författare)
-
Flocculation and Flotation to Recover Protein-Enriched Biomasses from Shrimp Boiling and Peeling Process Waters: A Case Study
- 2020
-
Ingår i: ACS Sustainable Chemistry & Engineering. - : American Chemical Society (ACS). - 2168-0485. ; 8:26, s. 9660-9668
-
Tidskriftsartikel (refereegranskat)abstract
- A novel integrated process for the recovery of protein-enriched biomasses from shrimp boiling water (SBW) and shrimp peeling water (SPW) was investigated by combining flocculation (F) and dissolved air flotation (DAF) into an F-DAF process. Alginate and carrageenan were used as flocculants. It was found that the protein yield from SPW and SBW in the F-DAF process was 68-97% and 26-45%, respectively. This led to a reduction in protein content of the influent SBW and SPW (12.4 and 1.4 g/L, respectively) by up to 76% and 85%, resulting in outlets with 2.9 and 0.2 g/L protein, respectively. Further, the F-DAF recovery process concentrated the proteins of SBW and SPW up to 7 and 29 times, respectively, thus, generating a protein-enriched biomass. After spray drying, biomass from SBW had up to 61% proteins and out of the total amino acids, up to 47% were essential ones. Further, the spray dried powder contained up to 23% total lipids, 2.7% long chained n-3 polyunsaturated fatty acids and 49.7 mg/g total astaxanthin. The studied F-DAF recovery system can thus be successfully used for recovering nutrients from process waters generated during the production of peeled shrimps.
|
|
| 2. |
- Hedén, Ida, 1984, et al.
(författare)
-
Dietary replacement of fishmeal with marine proteins recovered from shrimp and herring process waters promising in Atlantic salmon aquaculture
- 2023
-
Ingår i: Aquaculture. - 0044-8486. ; 574
-
Tidskriftsartikel (refereegranskat)abstract
- There is a general agreement that fish meal (FM) and fish oil (FO) are valuable resources for aquafeed, but that the production cannot keep the same pace as the current growth of the aquaculture industry. Therefore, there is a need to find alternative sources for lipids and protein. This study examines the possibility of using proteins recovered from seafood industry side stream waters as a complement to FM in feed for Atlantic salmon. To recover the proteins, herring and shrimp process side streams waters were flocculated then treated with dissolved air flotation (DAF), which is considered a gentle technology. Shrimp steam water was used to obtain shrimp protein (SP) and herring salt brine to obtain herring protein (HP). The recovered semi-solid protein fraction was spray dried and formulated into experimental diets at inclusion levels of 1.9–10% (dw/dw). Two feeding trials were conducted to investigate; 1) the properties of different flocculants to recover SP from shrimp steam water, alginate (Alg; 1.9% inclusion), carrageenan (Carr; 2.0% inclusion) and a synthetic flocculant from Kemira (Kem; 3.8% inclusion). 2) total or partial replacement of FM with SP-Alg (10% and no FM) and HP-Alg (3% and 8% FM). For both feeding trials each diet was provided to triplicate tanks (n = 31 and 30/tank) of Atlantic salmon with a start weight of 193 g (duration 10 weeks) and 304 g (duration 7 weeks) respectively. All fish showed similar feed intake, feed conversion ratio (on tank basis) and weight gain. The inclusion of SP or HP as total or partial replacement of FM did neither influence adiposity of the fish, as measured by condition factor, nor heposomatic index (HSI). No negative effect of the alternative protein could be found through histological examination of the intestine. In feeding trial two, diets did not affect the adaptive immune indicators CD8α and MHC II. The SP-Alg diet did not affect intestinal barrier and transporting functions, assessed using Ussing-chamber technology. However, HP-Alg affected the trans-epithelial resistance, which indicate that the intestinal barrier function could be affected by low inclusions. We conclude that from a biological perspective, SP recovered from shrimp steaming waters using Alg and DAF technology represents a new marine biomass with potential as a replacement for FM in Atlantic salmon feed. To diversify the possibility of using flocculants to retrieve proteins we also suggest further investigation of the potential to use Carr in larger inclusions.
|
|
