Aging of Cu/SSZ-13 for NH3 SCR in mixed lean condition

• Two catalytic methods have been developed to remove the NOx emissions from diesel vehicles and comply with the emission regulations: the NOx storage and reduction process (NSR) and the reduction of NOx with NH3 (SCR). Advanced systems combining these two methods for an optimum efficiency are now studied. SCR catalysts are subjected alternating lean and rich conditions as well as to high temperatures in rich conditions during deSOx of the LNT material. The purpose of the present work is therefore to determine the response of a Cu/SSZ-13 to several aging treatments at 800°C involving rich and/or lean exposure. Deactivation was observed after all types of aging. However strong differences in deactivation degree exists between aging procedures. Lean aging, for 8h at 800°C, was the most moderate aging tested although it brought about significant activity loss below 250°C. Alternating between long lean periods and short rich periods caused slightly stronger deactivation, which was most significant at 200°C. However, the switching frequency between lean and rich had negligible influence on subsequent activity. As shown in Figure 1, SCR activity after 8h exposure in H2 was outstandingly low. It increased monotonically with temperature to reach a maximum of 58% NO conversion. Further investigation pertaining to the rich treatment was performed. The aging time was reduced to 2h and, for direct comparison, a 32h cycling aging was performed, implying a total rich time of 2h. Both samples were severely impacted over the whole temperature range. It revealed that 2h in rich conditions led to stronger deactivation than 8h in lean and lean/rich conditions, emphasizing the deterioration power of H2. Aging caused by rich conditions was so dominant that additional 30h in lean has negligible influence on SCR below 300°C. However, the long additional exposure to lean conditions lowered significantly the SCR activity between 400 and 500°C.

Ämnesord

TEKNIK OCH TEKNOLOGIER  -- Kemiteknik -- Kemiska processer (hsv//swe)

ENGINEERING AND TECHNOLOGY  -- Chemical Engineering -- Chemical Process Engineering (hsv//eng)

TEKNIK OCH TEKNOLOGIER  -- Naturresursteknik -- Annan naturresursteknik (hsv//swe)

ENGINEERING AND TECHNOLOGY  -- Environmental Engineering -- Other Environmental Engineering (hsv//eng)

TEKNIK OCH TEKNOLOGIER  -- Kemiteknik -- Annan kemiteknik (hsv//swe)

ENGINEERING AND TECHNOLOGY  -- Chemical Engineering -- Other Chemical Engineering (hsv//eng)

Nyckelord

NH3-SCR

aging

deactivation

Cu-SSZ13

Publikations- och innehållstyp

kon (ämneskategori)

vet (ämneskategori)