Sökning: onr:"swepub:oai:DiVA.org:liu-120391" >
Cu diffusion in sin...
Cu diffusion in single-crystal and polycrystalline TiN barrier layers : A high-resolution experimental study supported by first-principles calculations
-
- Mühlbacher, Marlene, 1987- (författare)
- Linköpings universitet,Tunnfilmsfysik,Tekniska fakulteten,Montanuniversität Leoben, Austria
-
- Bochkarev, Anton S. (författare)
- Materials Center Leoben Forschung GmbH, Austria
-
- Mendez-Martin, Francisca (författare)
- Montanuniversität Leoben, Austria
-
visa fler...
-
- Sartory, Bernhard (författare)
- Materials Center Leoben Forschung GmbH, Austria
-
- Chitu, Livia (författare)
- Materials Center Leoben Forschung GmbH, Austria
-
- Popov, Maxim N. (författare)
- Materials Center Leoben Forschung GmbH, Austria
-
- Puschnig, Peter (författare)
- University of Graz, Austria
-
- Spitaler, Jürgen (författare)
- Materials Center Leoben Forschung GmbH, Austria
-
- Ding, Hong (författare)
- Lawrence Berkeley National Laboratory, CA, USA
-
- Schalk, Nina (författare)
- Montanuniversität Leoben, Austria
-
- Lu, Jun (författare)
- Linköpings universitet,Tunnfilmsfysik,Tekniska fakulteten
-
- Hultman, Lars (författare)
- Linköpings universitet,Tunnfilmsfysik,Tekniska fakulteten
-
- Mitterer, Christian (författare)
- Montanuniversität Leoben, Austria
-
visa färre...
-
(creator_code:org_t)
- American Institute of Physics (AIP), 2015
- 2015
- Engelska.
-
Ingår i: Journal of Applied Physics. - : American Institute of Physics (AIP). - 0021-8979 .- 1089-7550. ; 118:8
- Relaterad länk:
-
https://urn.kb.se/re...
-
visa fler...
-
https://doi.org/10.1...
-
visa färre...
Abstract
Ämnesord
Stäng
- Dense single-crystal and polycrystalline TiN/Cu stacks were prepared by unbalanced DC magnetron sputter deposition at a substrate temperature of 700 °C and a pulsed bias potential of -100 V. The microstructural variation was achieved by using two different substrate materials, MgO(001) and thermally oxidized Si(001), respectively. Subsequently, the stacks were subjected to isothermal annealing treatments at 900 °C for 1 h in high vacuum to induce the diffusion of Cu into the TiN. The performance of the TiN diffusion barrier layers was evaluated by cross-sectional transmission electron microscopy in combination with energy-dispersive X-ray spectrometry mapping and atom probe tomography. No Cu penetration was evident in the single-crystal stack up to annealing temperatures of 900 °C, due to the low density of line and planar defects in single-crystal TiN. However, at higher annealing temperatures when diffusion becomes more prominent, density-functional theory calculations predict a stoichiometry-dependent atomic diffusion mechanism of Cu in bulk TiN, with Cu diffusing on the N sublattice for the experimental N/Ti ratio. In comparison, localized diffusion of Cu along grain boundaries in the columnar polycrystalline TiN barriers was detected after the annealing treatment. The maximum observed diffusion length was approximately 30 nm, yielding a grain boundary diffusion coefficient of the order of 10‑16 cm2s-1 at 900 °C. This is 10 to 100 times less than for comparable underdense polycrystalline TiN coatings deposited without external substrate heating or bias potential. The combined numerical and experimental approach presented in this paper enables the contrasting juxtaposition of diffusion phenomena and mechanisms in two TiN coatings, which differ from each other only in the presence of grain boundaries.
Ämnesord
- TEKNIK OCH TEKNOLOGIER -- Materialteknik (hsv//swe)
- ENGINEERING AND TECHNOLOGY -- Materials Engineering (hsv//eng)
Nyckelord
- Diffusion
- TiN
- Microstructure
- Transmission electron microscopy
- TEM
- Atom probe tomography
- APT
Publikations- och innehållstyp
- ref (ämneskategori)
- art (ämneskategori)
Hitta via bibliotek
Till lärosätets databas
- Av författaren/redakt...
-
Mühlbacher, Marl ...
-
Bochkarev, Anton ...
-
Mendez-Martin, F ...
-
Sartory, Bernhar ...
-
Chitu, Livia
-
Popov, Maxim N.
-
visa fler...
-
Puschnig, Peter
-
Spitaler, Jürgen
-
Ding, Hong
-
Schalk, Nina
-
Lu, Jun
-
Hultman, Lars
-
Mitterer, Christ ...
-
visa färre...
- Om ämnet
-
- TEKNIK OCH TEKNOLOGIER
-
TEKNIK OCH TEKNO ...
-
och Materialteknik
- Artiklar i publikationen
-
Journal of Appli ...
- Av lärosätet
-
Linköpings universitet